Repair and Diagnosis (Single Page): Maintenance: Procedures: General
- How To Use This Service Information
- Troubleshooting Guidelines
- How To Use Troubleshooting/Inspection Service Points
- Troubleshooting Contents
- Notes
- 1. Standard Flow Of Diagnostic Troubleshooting
- 2. System Operation And Symptom Verification Tests
- 3. Diagnostic Function
- 4. Diagnostic Trouble Code Chart
- 5. Symptom Chart
- 6. Diagnostic Trouble Code Procedures
- 7. Symptom Procedures
- 8. Service Data Reference Table
- 9. Check At Ecu Terminals
- 10. Inspection Procedures Using An Oscilloscope
- How To Use The Inspection Procedures
- Connector Measurement Service Points
- Connector Inspection Service Points
- How To Cope With Intermittent Malfunctions
- How To Treat Past Trouble
- Inspection Service Points For A Blown Fuse
- Troubleshooting Contents
- Vehicle Identification
- General Data And Specifications
- Precautions Before Service
- CAUTIONS FOR WORKING IN ENGINE COMPARTMENT (2.0 L ENGINE Turbo)
- Supplemental Restraint System (SRS)
- How To Perform Vehicle Identification Number (VIN) Writing
- Initialization Procedure For Learning Value In MFI Engine
- Engine Idling Learning Procedure
- TIMING CHAIN MAINTENANCE (2.0 L ENGINE Turbo)
- Servicing Electrical System
- Vehicle Washing
- Application Of Anti-Corrosion Agents And Undercoats
- Scan Tool (Multi Use Tester {M.U.T.-III} Sub Assembly)
- Bolts And Nuts With Stabilizer For Coefficient Of Friction
- Coding List
- Towing And Hoisting
- Tightening Torque
- Lubrication And Maintenance
- Recommended Lubricants And Lubricant Capacities Table
- Scheduled Maintenance Table
- Maintenance Service (2.0L Non-Turbo Engine, 2.4L Engine)
- 1. Fuel System (Tank, Pipe Line And Connection, And Fuel Tank Filler Tube Cap) (Check For Leaks)
- 2. Fuel Hoses (Check Condition)
- 3. Air Cleaner Element (Replace)
- 4. Evaporative Emission Control System (Except Evaporative Emission Canister) (Check For Leaks And Clogging)
- 5. Spark Plugs (Replace)
- 6. Intake And Exhaust Valve Clearance (Inspect And Adjust)
- 7. Drive Belt (For The Generator And Power Steering Oil Pump) (Check Condition)
- 8. Exhaust System (Connections Portion Of Muffler, Muffler Pipes And Converter Heat Shields) (Check And Service)
- 9. Engine Oil (Change)
- 10. Engine Oil Filter (Replace)
- 11. Transaxle Oil
(Check Oil Level And Condition) - 12. Transmission Fluid
(Change Fluid) - 13. Engine Coolant (Change)
- 14. Coolant Hoses (Radiator Hose, Heater Hose) (Inspect)
- 15. Disk Brake Pads And Rotors (Inspect For Wear)
- 16. Rear Drum Brake Linings And Rear Wheel Cylinders (Inspect For Wear And Leaks)
- 17. Brake Hoses (Check For Deterioration Or Leaks)
- 18. Ball Joint And Steering Linkage Seals (Inspect For Grease Leaks And Damage)
- 19. Drive Shaft Boots (Inspect For Grease Leaks And Damage)
- 20. Suspension System (Inspect For Looseness And Damage)
- 21. Tires (Rotate)
- 22. Air Filter (Replace)
- Maintenance Service (2.0L Turbo Engine)
- 1. Fuel System (Tank, Pipe Line And Connection, And Fuel Tank Filler Tube Cap) (Check For Leaks)
- 2. Fuel Hoses (Check Condition)
- 3. Air Cleaner Element (Replace)
- 4. Evaporative Emission Control System (Except Evaporative Emission Canister) (Check For Leaks And Clogging)
- 5. Spark Plugs (Replace)
- 6. Intake And Exhaust Valve Clearance (Inspect And Adjust)
- 7. Drive Belt (For The Generator And Power Steering Oil Pump) (Replace)
- 8. Exhaust System (Connections Portion Of Muffler, Muffler Pipes And Converter Heat Shields) (Check And Service)
- 9. Engine Oil (Change)
- 10. Engine Oil Filter (Replace)
- 11. Twin Clutch SPORTRONIC Shift Transmission [Check Oil Leaks (If Necessary, Check The Oil Level)/Change]
- 12. Transfer Oil (With Active Center Differential) (Check Oil Level/Change)
- 13. Reserve Tank Fluid (For Active Center Differential) (Check Fluid Level)
- 14. Engine Coolant (Change)
- 15. Coolant Hoses (Radiator Hose, Heater Hose) (Inspect)
- 16. Disk Brake Pads And Rotors (Inspect For Wear)
- 17. Brake Hoses (Check For Deterioration Or Leaks)
- 18. Ball Joint And Steering Linkage Seals (Inspect For Grease Leaks And Damage)
- 19. Drive Shaft Boots (Inspect For Grease Leaks And Damage)
- 20. Suspension System (Inspect For Looseness And Damage)
- 21. Rear Axle Oil (With LSD) (Change)
- 22. Tires (Rotate)
- 23. Air Purifier Filter (Replace)
- Main Sealant And Adhesive Table