Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 04V332000: Front Coil Spring Corrosion
- Recall - Front Coil Spring Protective Shield
- Recall 02V266000: Accelerator/Brake Pedal Modification
- Recall - Brake/Accelerator Pedal Lateral Space Defect
- Recall - Headlamp Switch Knob Replacement
- Recall 01V075000: Headlamp Switch Knob Defect
- Recall 01V078000: Stop Lamp Switch Contamination
- Recall 04V106000: Stop Lamp Switch/Wiring Defect
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Recall 00V242000: Safety Label Non-Compliance
- Recall - Supplemental Safety Certification Label
- Customer Interest
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- EATC - No Setpoint/Blower Stays on HIGH
- A/T - TCC Not Engaging, DTCs P0741 or P1744
- Engine - Oil Leak Service Tips
- Body - Power Window Grunting Noise
- Power Windows - Stick/Do Not Operate
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - No Start/Hard Start/Rough Idle
- Engine - Spark Knock During Heavy Acceleration
- A/T - AX4N Closed Throttle Surging Condition
- Engine Controls - Spark Knock on Acceleration
- Brake Lamps - Remain Illuminated
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Exhaust System - Groaning, Buzzing/Rattling Noise
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Headlamp/Tailamp - Moisture in Lens Assembly
- A/T - Harsh 3-2 Downshift/Shudder On Acceleration/Turns
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- A/T - Inadvertent Shift Interlock Disabling
- A/C - Erratic Cool/Warm Function Operation
- A/C - Heater Core Electrolysis/Leakage
- A/T - Erratic Fluid Level Readings/Filler Tube Leaks
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Superceded Bulletins
- 02M01 - 01/01/04
- 02M01 - 11/01/03
- Body - Power Window 'Grunting' Noise
- Rear Window Defroster - Inoperative
- Body - Aluminum Corrosion Service Tip
- Passive Antitheft System (PATS) - Diagnostics Tips
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Restraint System - Seat Belts Slow to retract
- Recall - Front Coil Spring Shield Installation
- 04S17S1 - 12/22/04
- Recall - Coil Spring Protective Shield Installation
- Campaign - Front Coil Spring Replacement/Warranty Ext.
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Recall - Brake Lamp Switch Replacement
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- A/T - Erratic Fluid Level Reading/Leaks at Dipstick Tube
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON, DTC's P0401, P1400 or P1401
- Emissions - MIL ON/DTC's Set/Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- Exhaust Pipe - Groaning/Buzzing/Rattling Noise
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Engine Oil Pan - Oil Leaks After Repair
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Engine - Lower Engine Oil Leaks
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- Emissions- DTC's Set/MIL ON/Driveability Concerns
- All Technical Service Bulletins
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- A/C - Incorrect R134A Charge Level Label
- EATC - No Setpoint/Blower Stays on HIGH
- A/C System - Diagnosis and Service Tips
- A/T - TCC Not Engaging, DTCs P0741 or P1744
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Campaign - Possible Camshaft Fracture (Revision)
- Campaign - Camshaft Inspection Revision
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Engine - Oil Leak Service Tips
- Recall 04V332000: Front Coil Spring Corrosion
- Campaign - Front Coil Spring Extended Warranty
- Recall - Front Coil Spring Protective Shield
- Wheels/Tires - Road Force Measurement Equipment
- Body - Power Window Grunting Noise
- Power Windows - Stick/Do Not Operate
- A/T - Cooler Flushing Service Tips
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - Buck/Jerk/Miss Above 3,000 RPM
- Emissions/Engine Controls - Driveability Diagnosis
- Emissions - MIL ON/Driveability Issues/DTC's Set
- Engine Controls - No Start/Hard Start/Rough Idle
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine - Spark Knock During Heavy Acceleration
- A/T - AX4N Closed Throttle Surging Condition
- Campaign - Powertrain Control Module Reprogramming
- Engine Controls - Spark Knock on Acceleration
- Engine Controls - General PCM Programming Procedures
- Recall 02V266000: Accelerator/Brake Pedal Modification
- Recall - Brake/Accelerator Pedal Lateral Space Defect
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- Body - Power Window Service Tips
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Recall - Headlamp Switch Knob Replacement
- Recall 01V075000: Headlamp Switch Knob Defect
- Recall 01V078000: Stop Lamp Switch Contamination
- Brake Lamps - Remain Illuminated
- Recall 04V106000: Stop Lamp Switch/Wiring Defect
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Engine Head Gasket - Approved Replacement Procedures
- Engine - Oil Pan Gasket Replacement Revision
- PATS System - Diagnostic Service Tips
- Recall 00V242000: Safety Label Non-Compliance
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Exhaust System - Groaning, Buzzing/Rattling Noise
- Engine Controls - MIL ON/Lean DTC Service Tips
- Body - Power Lock Service Tips
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Body - Exterior Mirror Glass/Motor Service Tips
- Headlamp/Tailamp - Moisture in Lens Assembly
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - AX4S Prior to Service Blue Repair Tag
- Transaxle - AX4N Prior to Service Green Repair Tag
- A/T - Harsh 3-2 Downshift/Shudder On Acceleration/Turns
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Recall - Supplemental Safety Certification Label
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Locks - Lock Service Packages Available
- A/T - Inadvertent Shift Interlock Disabling
- A/T - AX4S/AX4N Redesigned Park System
- Seat Belts - Warning System Operation
- A/C - Identification of Non Approved Refrigerants
- Brakes - Vibration/Inspection Service Tips
- A/C - Erratic Cool/Warm Function Operation
- A/C - Heater Core Electrolysis/Leakage
- Body - Aluminum Body Panels - Corrosion
- Keyless Entry - Keypad Diagnostics
- A/T - Erratic Fluid Level Readings/Filler Tube Leaks
- Steering - Mercon V(R) Fluid Usage
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose