Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Air Conditioning - Musty/Mildew Type Odors
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes - Roughness During Application
- Steering Gear - Clunk/Knock Noise While Turning
- A/T - CD4E Fluid Leak From Fill Tube/Seepage From Vent
- A/T - CD4E Harsh Shift/DTC 678 or P0741 Set
- A/T - 4EAT Harsh 1-2 Upshift
- A/T - CD4E Transaxle Pump Seal Fluid Leak
- MAF Sensor - MIL ON/DTC's Set/Driveability Concerns
- Engine - Lean Driveability Symptoms
- Axle Shafts - Fluid Leaks
- Instrument Cluster Warning Lights - Dimly Lit
- Engine - Hard Start/Stall After Hot Soak
- Headlamp Door - Erratic or intermittant Operation
- Air Bag System - Error Code 51Diagnostics/Repair
- Electronic Fuel Gauge - Erratic Readings
- Engine - Hard/No Start/Fuel Shutoff Lamp Illuminated
- Radio - Front Door Speakers Inoperative
- Liftgate Shock - Will Not Support Liftgate
- Sliding Roof Panel - Rattle/Squeak/Creak Noise
- Front Door Glass - Wind Noise/Water Leaks
- Door Glass - Water Leaks/Wind Noise
- Rear View Mirror - Detaches From Windshield
- Air Dam - Skirt Loose At Front Crossmember
- Exhaust System - Buzzing/Rattling Noise
- A/T - No Forward Gear Engagement
- Engine - Drone Noise From Engine Mount
- A/C - Poor Performance When Hot
- A/T - CD4E Harsh and Delayed Upshifts/DTC's Stored
- Instrument Panel - Rattling/Buzzing Noise
- Rear Cylinder Head - Tapping Noise
- Engine - Tapping Noise
- Power Door Locks/Windows - Inoperative
- Door Locks - Inoperative In Below Freezing Temperatures
- A/T - Inadvertent Shift Interlock Disabling
- A/T - CD4E Whistle Noise in Park
- Combination Switch - Slow to Cancel After Left Turns
- Steering Wheel - Off Center After Hard Turn
- Chemicals,Additives
- Factory Modifications
- Labor/Parts Updates
- Superceded Bulletins
- 97-14-12 - 07/07/97
- 97-14-11 - 07/07/97
- Front Door Glass - Water Leak/Wind Noise
- Leather Seat - Cleaning Procedure Tips
- Seat Leather - Cleaning Procedure
- Sliding Roof Panel - Rattle/Squeak/Creak Noise
- A/C - Musty and Mildew Type Odors
- A/C - Identification Of Non Approved Refrigerants
- Air Conditioning - Musty Odors
- A/C - Approved Flushing Procedures
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Engine - Hard Start or No Start
- Brakes - Special Lubricant Requirements
- Brakes - Roughness/Vibration
- Brake Rotor - Hub Mounted Machining Equipment
- Brakes - Rotor/Drum Sanding Elimination
- A/T - New Transmission Cooler Flusher/Service Tip
- A/T - CD4E Harsh Shift/Engagement/DTC 628 or P0741
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- A/T - CD4E Fluid Seeping at Vent
- A/T - CD4E Fluid Seeping from Vent
- A/T - 4EAT Harsh 1-2 Shift
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel - Volatility Related Concerns
- Fuel Economy - Expectations Versus Usage
- Speaker - Whining/Buzzing Noise
- Fuel Pump and Bracket - Return of Obsolete Parts
- Speakers - Whining/Buzzing Noise
- Radio - Whine/Buzz
- Fuel - Volatility Related Driveability Information
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Exhaust System - Buzz/Rattle Noise
- Heater Core - Repeated Failure
- Engine, A/T - CD4E Buzz/Vibration or Clicking/Vibration
- Engine - Tapping Noise From Rear Cylinder Head
- Engine - Oscillating Noise
- A/T - Fluid Application Charts
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Propylene Glycol Coolant - Recommendations
- Recycled Engine Coolant - Service Tip
- Propylene Glycol Coolant - Recommendation
- A/T- CD4E Service Units Low Fluid Warning
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - Filter Kit Installation After Replacing Compressor
- A/C Compressor Replacement - Refrigerant Filtering
- Air Conditioning - Filtering Refrigerant
- A/C - R134A Tracer Dye Factory Installed
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- Vehicle - Towing Guidelines
- Engine - Hard Start/Stall after Hot Soak
- All Technical Service Bulletins
- Vehicle - Towing Behind RVs Guidelines
- A/C System - Service TSB List
- Air Conditioning - Musty/Mildew Type Odors
- A/C - Filtering Refrigerant After Compressor Replacement
- Engine - Knock/Clatter/Tick/Tap Noise, Service Tip
- Electrical - New Terminal Grease Released For Service
- Fuel Pump - Whine Heard Through Radio Speakers
- Fuel Pump/Bracket Assembly - Obsolete Parts Return
- Fuel Gauge - Reads Inaccurately
- Campaign - Fuel Pump/Sender Modification
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes - Roughness During Application
- Brake and Rotor - Service Tips
- A/C Evaporator Core - On Vehicle Leak Test Requirement
- Air Conditioning - Approved Flushing Procedures
- Heater Core - On Car Pressure Test For Warranty Claim
- Steering Gear - Clunk/Knock Noise While Turning
- Cylinder Head/Piston - Modification
- Engine - Knocking/Clattering/Ticking/Tapping Noises
- Water Pump/Pulley - Design Modification
- Cooling System - New System Diagnostics
- Radiator - New Manufacturing Process
- Lug Nuts - Proper Installation/Torqueing Procedure
- Door - Replacement Service Procedure
- A/T - CD4E Fluid Leak From Fill Tube/Seepage From Vent
- A/T - CD4E Forward Clutch Circuit Filter Service Tip
- A/T - CD4E Harsh Shift/DTC 678 or P0741 Set
- A/T - 4EAT Harsh 1-2 Upshift
- A/T - CD4E Transaxle Pump Seal Fluid Leak
- A/T - CD4E Harsh Shift and/or Engagement Tip
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Cooler Flushing Service Tips
- A/T Torque Converter - Leak Test Procedure
- Fuel Injectors - Non Warranty Reimbursement Testing
- EGO Sensors - Silicone Contamination
- Mass Air Flow Sensor - Assembly Replacement
- MAF Sensor - MIL ON/DTC's Set/Driveability Concerns
- Engine - Lean Driveability Symptoms
- Axle Shafts - Fluid Leaks
- Instrument Cluster Warning Lights - Dimly Lit
- Engine - Hard Start/Stall After Hot Soak
- Campaign - Engine Water Ingestion
- Power Window Switches - Obsolete Part Return
- Headlamp Door - Erratic or intermittant Operation
- Air Bag Modules - Discolored/Marred Covers
- Recall - Passenger Air Bag Module Replacement
- Recall 93V169000: Passenger Airbag Defect
- Air Bag System - Error Code 51Diagnostics/Repair
- Brake Rotor - Machining Equipment/Warranty Information
- Brakes - Elimination Of Sanding Rotors And Drums
- Hub-Mount Brake Rotor Machining Equipment
- Electronic Fuel Gauge - Erratic Readings
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- Engine - Hard/No Start/Fuel Shutoff Lamp Illuminated
- Radio - Front Door Speakers Inoperative
- Liftgate Shock - Will Not Support Liftgate
- Sliding Roof Panel - Rattle/Squeak/Creak Noise
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Front Door Glass - Wind Noise/Water Leaks
- Door Glass - Water Leaks/Wind Noise
- Rear View Mirror - Detaches From Windshield
- Rear View Mirror - Reattachment
- Air Dam - Skirt Loose At Front Crossmember
- Motor Oil - Viscosity Grade Recommendation
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- A/T - No Forward Gear Engagement
- A/T - CD4E Coast Clutch Piston Seal Service Tip
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - CD4E Service Units Shipped With Low Fluid Level
- A/T - Transmission Flush and Fill Tool Available
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - G4AEL, G4AHL, F4EAT, F4AEL Shift Feel Complaints
- A/T - Failsafe Modes
- A/T - Slipping/Vehicle Does Not Move After Rebuild
- A/T - Low OR No Line Pressure Rise/Worn Throttle Cam
- A/T - 4EAT, G4A-EL Engine Stalls In Drive
- A/T - Reverse Piston Return Spring Revised
- A/T - G4AEL/4EAT DTC 60, 61, 62, or 63/Pinched Wires
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - G4A-EL, 4EAT Engagement Problems
- A/T - G4A-EL 3-4 Shift Hunt
- A/T - G4A-EL and F4EAT Trouble Code Identification
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Revised EGR Valve Wiring Harness
- Engine - Drone Noise From Engine Mount
- A/T - Mercon V ATF Usage
- A/C - Poor Performance When Hot
- A/T - CD4E Harsh and Delayed Upshifts/DTC's Stored
- Instrument Panel - Rattling/Buzzing Noise
- Rear Cylinder Head - Tapping Noise
- Engine - Tapping Noise
- Engine - New Gasket Sealer
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Remote Keyless Entry System - Service Highlights
- Remote Keyless Entry System - Service Tips
- Remote Keyless Entry - Diagnostic Service Tips
- Keyless Entry System - Service Tips
- Power Door Locks/Windows - Inoperative
- Door Locks - Inoperative In Below Freezing Temperatures
- Paint - Codes/Cross References
- Paint - Preparation Procedure And MSDS Information
- Paint - Iron Particle Removal
- A/T - Inadvertent Shift Interlock Disabling
- Electrical Diode - Identification and Replacement
- A/T - CD4E Whistle Noise in Park
- Engine Seal Plate - Modification
- A/T - CD4E Servo Cover/Service Tool and Tips
- Combination Switch - Slow to Cancel After Left Turns
- Glove Compartment - Improved Lock
- A/T - CD4E Alignment Tabs On Cover Pan
- Campaign - Keyless Entry System Transmitters
- A/C - Release of R134a Fluorescent Dye
- A/C - Identification of Non Approved Refrigerants
- Air Conditioning - O Ring Removal Service Tip
- A/C O Ring - Availability and Applications
- A/C - New O Ring Applications
- Steering Wheel - Off Center After Hard Turn
- Brakes - New Silicone Compound/Grease
- Brakes - Vibration/Inspection Service Tips
- A/C - Oil Visible At Spring Lock Couplers
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- Campaign - Owners Guide Revision
- A/C - Adding Refrigerant Oil Service Tip
- A/C - Refrigerant Oil Refill Capacity
- Seat Leather - Cleaning Procedure Tips